After a cold winter

After a cold winter my Vanagon refuse to start.
Check ignition was ok,
Check fuel injection - no fuel
Tried to track down pump wiring, no luck.
Hot wired pump directly to battery, no luck
Remove original fuel pump and tried again, it dead!
Part number 0 580 463 010
Estimate replacement cost $150........

3/31/2015
Removed both rear tires to track down fuel pump wires, still can not find how the pump is wired to relay.

Summer 2015
I gave up and sold my Vanagon for $600

New Tire for September 2014

Brought new front tire for my Vanagon.
Falken Sincera 828

http://www.discounttire.com/dtcs/tires/falken/product/submitProductSize.do?r=IADINT|pc|52803&pc=18003

It took me 2 days to loosen the lug nuts

Plan on buying another next month.

Battery loses charge

Last day of June 2014 took my Vanagon for Highway ride.  It rode smooth and ran good.  Pick up a friend on way back to take her to store. Had to wait 10 mins and then the  battery fail to turn over.  Had her push it backward 10 ft to jump start.  Need to do wiring check for short circuits, buy another used battery for backup jumps, and buy a battery charge.

Happens again in August, I think I might have wrong battery.  Going to clean electrical terminals on starter, fuse box connection, and Alternator.

July 24, 2014

Washed roof of the Vanagon, remove lots of crud.

 Today it was starting and running rough.

Change distribute cap and rotors - still ran fast.  Notice loose fitting on throttle hose, when I push it in the engine ran lot better.  Need to clean entire throttle housing.

Now it time to camping and fishing!

Under the Front End

Under the front end

Removing A/C radiator from the bottom, found water in wiring going to radiator fan.

Re install coolant radiator

Test drive, now coolant red light goes out.

June projects

Bleeded the radiator

  Do I need AC radiator when there is no AC compressor?

 

Heater Fan Wiring

May 19, 2014

Heater fan would run all the time, as if it was by-pass at switch.  Removed fuse panel and found relay panel and a hot wire for fan circuit.  Disconnect long red wire at yellow connector and fan stop running.  Going to check radiator fan circuit next.

Next project, to figure out why it is so hard to shift in 1st or 2nd gear.  Going to remove front tire carrier and check out gear selection box.

My Mental Therapy